Skip to main content

Prepare the New Fill Valve — Install New Fill Valve

Beginner2 hours

Part of project

How to Replace a Toilet Fill Valve and Flapper · Step 4 of 6

Helpful?

In this video

Before installing the new fill valve, adjust its height to match the old one or the requirements of your tank. This is usually done by twisting and extending the valve's shaft and securing it with a locking collar or pin. Also, identify the water level adjustment mechanism (often a screw or a float clip) and set it to a lower initial position. You can fine-tune it later once the water is on.

Goal: Adjust the new fill valve's height and water level settings before installation.

  • Matching the height of the new valve to the old one is a good starting point for proper installation.
216.6K views1.4K5 minutes
replumb

719K subscribers

View Channel

FAQs

What are the most important safety precautions I should take when replacing a toilet fill valve and flapper?

Always start by turning off the water supply to the toilet completely using the shut-off valve behind the toilet. Flush the toilet to drain the tank and bowl as much as possible. Have towels and a bucket ready to catch any residual water, and consider wearing gloves for hygiene and grip.

The project is rated 'beginner' and '2 hours.' Is this realistic for someone who has never done plumbing before?

Yes, this project is genuinely beginner-friendly. It primarily involves unscrewing and screwing on nuts by hand or with simple tools. While 2 hours is a good estimate, allow yourself a bit more time if it's your first time to read instructions carefully and avoid rushing. It's a great project to build confidence in DIY plumbing.

Do I need the specific Husky wrench and Channellock pliers mentioned, or are other adjustable wrenches sufficient?

You do not need those exact brands. Any good quality adjustable wrench (10-12 inches) will be essential for securing the fill valve nut. Slip-joint pliers are very helpful for removing stubborn connections but often an adjustable wrench can handle most tasks. Ensure your tools are in good working order.

After replacing the fill valve and flapper, my toilet is still running or leaking. What should I check first?

First, ensure the fill valve's water level adjustment is set correctly; the water should stop filling about 1 inch below the top of the overflow tube. Next, check that the flapper seats perfectly over the flush valve opening and that its chain isn't too tight or too loose, which could prevent a proper seal. Also, double-check that the fill valve mounting nut underneath the tank is tightened sufficiently but not overtightened.

Transcript
Hide

remove your fill valve. So this is my new fill valve and this will go inside of the tank. On the other side I'm gonna use this ring to hold it to the tank. So the tank is right here and also you can replace the washer if it comes with the washer because this will go right here on the bottom and this is how you're going to connect your water supply right here on the bottom. Also it's good idea to familiarize yourself with the adjustment of your fill valve. This particular one if you want to adjust the height of the water level what you do is you twist it and you can extend it or make it shorter. Okay so and once we set up the desire height we twist it until it locks and then we also have it encoded pen if you want to use it and we're going to slide right here just to mark this in a position. Then you cannot untwist it you cannot move it. Another adjustment that you may want to do if this is going to create too much level in your tank there's another pen that I can remove. I think there we go. So I pushed it out and now I can lower this or move it high. And the third adjustment that you can do is right on the top you have this screw that you can lower this point that's going to shut all the hole. Some kind of move it all the way down to the position. It's much easier to do now than later and we can always re-just it a little bit later. So I'm going to put this fill valve right here and I'm going to

Auto-generated transcript. May contain errors.