Skip to main content

Cutting Out the Damaged Pipe — Inspect and Repair (or Replace) Water Supply Lines

Beginner2 hours

Part of project

Fix a Dripping Bathroom Faucet: A Step-by-Step Guide · Step 3 of 4

Helpful?

In this video

To begin the permanent repair, shut off the main water supply. Use a pipe cutter to remove the damaged section of the copper pipe. Make clean, straight cuts on both sides of the damaged area to prepare for the new fittings.

Goal: Remove the leaking section of pipe

  • Always ensure the main water supply is turned off before cutting any water lines.

Used in this video

  • Pipe Cutter (Tool Type: Tubing Cutter)Cutting the copper pipe to remove the damaged section.
4.6K views2110 minutes
seejanedrill

1.1M subscribers

View Channel

FAQs

Why is a basin wrench specifically recommended for this project, and are there alternatives?

A basin wrench is essential because its long shaft and swiveling jaw allow you to reach and loosen nuts in cramped spaces under the sink, particularly those securing the faucet. While other wrenches might fit some nuts, a basin wrench is designed for the tight angles and often inaccessible positions encountered when working on faucets.

What are the common issues to watch for when reconnecting the water supply lines to avoid new leaks?

A common mistake is not tightening the connections enough, leading to slow drips, or over-tightening, which can strip threads or damage washers. Ensure the supply lines are hand-tightened, then use a wrench for a quarter to a half turn more. Always check for leaks immediately after turning the water back on and tighten slightly if needed.

What safety precautions should I take beyond just turning off the water supply?

In addition to shutting off the water, place the Unger 6 Gal. Heavy-Duty Plastic Bucket DB02 directly under your workspace to catch any residual water. Wear safety glasses to protect from drips or debris, and consider gloves for a better grip and to protect your hands from grime under the sink, especially in tight, dirty spaces.

My faucet is dripping from the spout, but this guide focuses on supply lines. Will this project fix that type of drip?

This specific guide primarily addresses leaks originating from the water supply lines or their connections to the faucet tailpieces. If your faucet is dripping from the spout itself, the issue is likely with internal components like worn-out O-rings, cartridges, or washers, which would require disassembling the faucet's body, not just inspecting the supply lines.

Transcript
Hide

it and utilize a socket so you can get it really tight. If you're wondering how I fixed this, let me show you. I wasn't going to try to solder it. So I settled on using shark bites, push fittings and using a piece of pecs pipe to connect the copper lines. I first sand it off all the copper lines. I cut the copper, then reamed the copper and used the brush to clean the

Auto-generated transcript. May contain errors.